ARB OME application catalogue

Contents!A1 REMARKS: QTY UNIT PRICE $ 2 QTY UNIT PRICE $ Contents!A1 REMARKS: QTY UNIT PRICE $ 1 2 1 QTY UNIT PRICE $ 1 2 1 2 QTY UNIT PRICE $ 2 2 + 2 2 2 NITROCHARGER SPORT - FK72 Swaybar Kit to lower the front swaybar DIESEL ENGINE Estimated Lift: 45mm (2 inch) SPRING: 75MM 3075 CASTER CORRECTION KIT FK81 NITROCHARGER SPORT 60121 PART NUMBER 2768 Estimated Lift: 75 - 100mm (3 inch to 4 inch) SPRING: 45MM FRONT 60123 DIESEL ENGINE NITROCHARGER SPORT When fitting either 3075 or 3076 it is mandatory to fit Bump Spacer Kit FK73 to prevent the coil from being over stressed. UCB5 2 OE spring bushes are required to fit CS042R springs. D10XL extra leaf should be fitted when a constant 200kg plus load is carried. Use OMEU78 when fitting to a vehicle with an overload leaf. - SPRING: 100MM 3076 FRONT 60121 PART NUMBER FORD SPRING: MEDIUM LOAD FORD F250 & F350 2011 TO 2017 D10XL Raise or lower front end clearance and trim vehicle by adjusting front torsion bars. Important: A minimum of 60mm of droop must be maintained. FRONT OME front shock 60121 is not suitable as an OE replacement. When fitting our longer OME shock 60121 you must fit: - FK71 Brakeline Kit to extend / drop the brakelines Fitment of a FK81 Caster Correction Kit will provide approximately 3.5 to 4.0 degrees of extra caster. It is advisable to have a front end alignment carried out to determine if a FK81 kit is required. 4 2 CENTRE BOLT- OVERLOAD ONLY UCB21 EXTRA LEAF U BOLTS - WITH OVERLOAD LEAF OMEU77 EL40XL PANHARD BRACKET OMEU78 Estimated Lift: 75mm (3 inch) FK74 SWAYBAR BRACKET KIT FK72 RADIUS ARM DROP BRACKET KIT SPRING BUSH KIT OMESB109 60122 U BOLTS - NO OVERLOAD LEAF PART NUMBER REAR ALL MODELS EL077R SPRING: CONSTANT 450 KGS SPRING: MEDIUM LOAD FK70 BRAKELINE BRACKET KIT FK71 BUMP SPACER KIT FK73 FK69 NITROCHARGER SPORT Estimated Lift: 40mm REAR N17 V6 PETROL ENGINE PART NUMBER N16 NITROCHARGER PART NUMBER CS042R NITROCHARGER 2 Use OMEU77 when fitting to a vehicle without an overload leaf. 1 - FK70 Radius Arm Drop Bracket Kit, if not fitted you may over stretch the front brakelines EL077R + EL40XL When bull bar and / or winch are fitted use FK74 on both coils to restore nominal lift height. EXTRA LEAF TRIM PACKET (10mm) FORD EXPLORER 1996 TO 2001 REAR LEAF SPRING MODELS TORSION BARS Where the OE rear leaf spring has an overload leaf fitted, this overload leaf is to be fitted to the OME leaf, EL077R is to have its centre bolt replaced with a longer bolt UCB21 and OE spacer blocks are to be reused. CENTRE BOLT 2 1 1 2 2 1 3 4 5 4 1 2 3 4 5 6 2 1 6 Page 42 OME INT CAT. NO.43 APRIL 2020